GB 4706.19-2008Household and similar electrical appliances -- Safety -- Particular requirements for heating liquids (English PDF)

Foreword

All technical content of this Part is mandatory.

GB 4706 "Household and similar electrical appliances - Safety" consists of

several parts. Part 1 is general requirements; the rest parts are special

requirements.

This Part shall be used with GB 4706.1-2005 "Household and Similar Electrical

Appliances - Safety - Part 1.General Requirements".

This Part equivalently adopts International Electrotechnical Commission IEC

60335-2-15.2005 "Household and similar electrical appliances - Safety - Part 2-

15 Particular requirements for appliances for heating liquids". (Edition 5.1,

2005-10). For easy use, this Part made the following editorial modifications to

IEC 60335-2-15.

a) modified "Part 1" as "GB 4706.1-2005";

b) used a decimal point "." to replace the comma "," that is used as a decimal

point.

This Part replaces GB 4706.19-2004 "Safety of household and similar electrical

appliances - Particular requirements for appliances of heating liquids".

Compared with GB 4706.19-2004, the main differences in this Part are as

follows.

- modified NOTE 105 in the scope. storage water heaters (GB 4706.12),

pressure sterilizers; added. humidifiers for household and similar use (GB

4706.48);

- added thermal pots, urns in article 3.1.9.101;

- modified NOTE 101 in 5.2.If the test of 15.101 has to be carried out, three

additional samples are required;

- modified 7.1 as. "unless they cannot be filled beyond their rated capacity";

- added the following in 7.12.For espresso coffee-makers incorporating a

pressurized reservoir filled by the user, the instructions shall contain

information for the safe refilling of the water reservoir and the substance

of the following.

WARNING. The filling aperture must not be opened during use.

- added the following in 15.2.For steam sterilizers, replace the penultimate

paragraph of this subclause of GB 4706.1-2005 by the following.

Steam sterilizers are placed on a horizontal surface and 30 mL of water

containing approximately 1% NaCl is poured onto the top rim in the most

unfavorable place. The solution is poured steadily through a tube having

an inner diameter of 8 mm over a period of 2 s, the lower end of the tube

being 200 mm above the appliance.

NOTE. A schematic representation of the test arrangement is shown in

Figure 101.

Addition. Kettles are then filled to rated capacity with water. They are

placed on a plane inclined at an angle of 20° to the horizontal with their

spout facing up the slope of the inclined plane. Water shall not be

discharged from the kettle.

- in 15.101, modified. "They are then completely immersed in water

containing approximately 1% NaCl and having a temperature between

10°C and 25°C";

- in 19.7, modification [Translator note. in the text, it is "19.7 Addition"].

"Espresso coffee-makers incorporating a pump are operated for a period

of 5 min";

- in 19.102, added. " NOTE. Subclause 19.13 is applicable";

- in 22.110, added. Espresso coffee-makers, incorporating a pressurized

reservoir filled by the user, shall be constructed so that there is no spillage

of water or sudden jets of steam or hot water likely to expose the user to

a hazard when the appliance is used in accordance with the instructions.

When removing the filling cap of the pressurized reservoir, before the cap

is removed completely, the pressure shall be relieved in a controlled

manner in order to avoid the emission of jets of steam or hot water that

are likely to expose the user to a hazard.

Compliance is checked by inspection during the test of Clause 11 and by

removing the filling cap at the end of the test.

- in 29.2, added. The microenvironment is pollution degree 3 if the insulation

can be polluted by condensation from steam produced during normal use

of the appliance.

This Part was proposed by China National Light Industry Council.

This Part shall be under the jurisdiction of National Technical Committee on

Household Appliances of Standardization Administration of China (SAC/TC 46).

Household and similar electrical appliances - Safety -

Particular requirements for heating liquids

1 Scope

This clause of GB/T 4706.1-2005 is replaced by the following.

This Part deals with the safety of electrical appliances for heating liquids for

household and similar purposes, their rated voltage being not more than 250 V.

NOTE 101.Some appliances may be used for heating food.

NOTE 102.Examples of appliances that are within the scope of this Part are

- coffee-makers;

- cooking pans;

- egg boilers;

- feeding-bottle heaters;

- kettles and other appliances for boiling water, having a rated capacity not exceeding

10 L;

- milk heaters;

- pressure cookers having a rated cooking pressure not exceeding 140 kPa and a rated

capacity not exceeding 10 L;

- slow cookers;

- steam cookers;

- wash boilers;

- yoghurt makers.

Appliances not intended for normal household use but which nevertheless may

be a source of danger to the public, such as appliances intended to be used by

laymen in shops, in light industry and on farms, are within the scope of this Part.

NOTE 103.Examples of such appliances are

......